How To Make Hard Cheese

To make about one pound of cheese, you will need the following ingredients:

2 gallons fresh milk (preferably raw)
1 cup cold water
3/4 Hansen's cheese rennet tablet, or 8 junket rennet tablets
2 tablespoons sea salt


Steps in cheese making:

Allow 1 gallon of the milk to ripen overnight in a cool place (50 to 60F). The next morning, add the other gallon. In a big, enamel or stainless-steel pot, warm the milk to 86F. Add tablet to the cold water, and stir until dissolved. Set the pot in a bigger vessel of warm water (88 to 90F), away from drafts. Add

rennet solution, and stir well. Let stand undisturbed until a firm curd forms—about 30 to 45 minutes. Test the firmness by delicately putting a finger into the curd at an angle and lifting it. If curd breaks neatly over your finger, it is ready to cut. If not, let it set 15 to 20 minutes longer.

Take out pot from larger vessel, and cut curd into 3/8-inch cubes. Use a knife with a blade long enough to cut through to the bottom of pot without the handle's touching the curd. Stir curd cubes carefully but thoroughly using a wooden spoon for about 15 minutes; use long, slow movements so curds are not crushed. Put the pot in a larger pot with water (forging a double-boiler effect), and heat gradually, raising curds' temperature about 1 1/2 degrees every 5 minutes until it reaches 102F. Stir with a wooden spoon to hold on the curds from sticking together. Remove from heat when curds start to hold their shape and easily fall apart when held, but not squeezed, together.

Stir every

5 minutes for about 1 hour (you read that right!) to keep curds from sticking. Leave them in the whey till the mass becomes so firm that a handful of pieces, when pressed together, will shake apart easily. Place the curds on a double layer of 3-foot-square cheesecloth, and pull corners of cloth together. Swing gently, allowing curds roll back and forth so whey drains without squeezing. Sprinkle curds with half of sea salt, and mix thoroughly with wooden spoon. Sprinkle on remaining sea salt, and mix in by hand.

Tie the cheesecloth so curds form a ball; hang up, and allow the whey to drip for 45 minutes. Remove cheesecloth; fold it into a rectangular bandage, 3 inches by 3 feet, and wrap tightly around the ball. Using your hands, press down on ball until top and bottom are flat. Put three or four layers of cheesecloth under and over the cheese. Place in press; adjust pieces of wood; put a heavy object on the press; let it sit overnight. Turn, then press overnight once more.

Take out the cheese from the press, and remove cheesecloth wrapping. Allow to stand in a warm room (70 to 75F) for 6 hours while rind forms and dries out. Then coat using hot, melted paraffin. Holding the cheese with tongs, dip one half and then the other half. Or paint on paraffin with a basting brush. An alternate to paraffin coating is rubbing vegetable oil into the cheese. Ripen in a cool place (50 to 65F) 3 to 4 weeks; turn two or three times each week.


Article Written By Athena

Freelance writer since 2007 Content Provider Musician Educator Homeschooling WAHM

Last updated on 23-06-2016 68 0

Please login to comment on this post.
There are no comments yet.